Specifications include, but are not limited to: 1. Service Group #1 - Oil / Filter Changes At every 5,000 miles change the oil and filter Use SAE 5-W-20 oil which meets SH, SJ standards. Check all fluids, brake master cylinder, power steering, transmission. Check air filter unit. Visual inspection of radiator and radiator cap. At operation temperature check the coolant level by observing lines on surge tank for proper fill. Visual inspection of radiator and heater hoses and all rubber vacuum lines. Check belts for fan, alternator, water pump and air conditioner for proper tension and signs of wear. Make under-hood check of all electrical wires and connections. Ensure area in front of radiator is clean and free of debris such as bugs, grass, etc. If equipped with grease fittings, lubricate steering, suspension, and ball joints. 2. Service Group #2 - Tire Rotation/Maintenance/Replacement Every 10,000 miles rotate tires on four-tire rotation basis. Visually inspect brakes when rotating tires. Check tire pressure regularly. Maintain at 35-44 PSI, cold. Replacement of tires with more than 3/32 inch of tread must be approved by Sheriff, Chief or Lieutenant. When wheels are taken off for any reason, torque wheel nuts to manufacturer’s specifications. Improper tightening of wheel nuts will warp the brake rotors and result in poor brake performance. Tires must be V speed rated. 3. Service Group #3 - Air Filters Every 15,000 miles replace the paper air filter element. Filter should be replaced immediately if the vehicle is exposed to severe dust conditions. 4. Service Group #4 - Fuel Filter and Other 15,000 Mile Adjustments Replace the fuel filter every 15,000 miles. 5. Service Group #5 - Cooling System Flush and fill cooling system at 100,000 miles. Use antifreeze all year round a check frequently during Winter months. Protection must be -20 degrees. Use only antifreeze which is yellow or green in color. Do not mix orange antifreeze with original yellow or green. 6. Service Group #6 - Transmission Every 50,000 miles flush all fluid and change the filter. 7. Service Group #7 - Spark Plugs Replace every 60,000 miles. 8. Service Group #8 - Brakes Replace brake pads as necessary with approved pads. Rotors should be replaced with new not resurfaced.
