CNCC is seeking proposals from qualified contractors for the purchase of 2 compartments 40' 0" long by 8'7" high walk-in Cooler/Freezer Combination. The full size walk-in contains 2,1419 internal cubic feet to assure maximum storage capacity.
4 yr extended Compressor Warranty 3.5-5HPS
18 mont Labor/Service Warranty
4 year extended Compressor Warranty 1.5-3HPS
18 month Labor/Service Warranty
15 yr walk-in panel Warranty
1 yr replacement parts warranty
Finishes:
26 Gauge Corrosion Resistant Stucco Embossed Coated Steel
26 Gauge Smooth Galvanized Ceiling topside and floor bottom side
.100 smooth aluminum-Interior floor
Freezer (-10.0°F) Details:
(1) 30" X 78_" Walk-In Door left-hand swing
Includes door closer, cam lift hinges (one spring loaded on 36" wide and smaller doors), NL9800 deadbolt key/padlock handle with inside release, magnetic gasket, heater wire, double sweep gasket, LED vapor proof light, Heated Air Vent (standard on all freezer compartments) and NL508 combination digital thermometer and switch w/pilot light. •
(1) Ramp to be Reinforced (Interior or Exterior Ramp)
(1) 30" Interior Ramp With Non-Skid Strips Applied To Top (24" Deep) Sq. Ft. Of 3/4" CDX Plywood Subfloor for Freezer (-10.0°F)
(1) MSLD0S0AB*
5HP Cond Unit 208-230/60/1 R-448A/R-449A, Outdoor Unit Scroll Compressor, Low Temp -10F., 12548 BTUH System Capacity. With Mounted Timer. Sized for 100 F. Temperature at Condenser. 30" (L) 31" (W) 26" (H) Base: M3@ 250#. MCA: 54, MOP: 70, RLA: 32, LRA: 169. Connections - Liquid: 0.5'', Suction: 0.875".
(1) E1LD0166B-TE2*
Evap 208-230/60/1 R-448A/R-449A, Elec Defrost Mtd TXV/Temp Ctrl/Sol, Low Temp -10F., 16600 BTUH Evaporator Capacity. 60" (L) 16" (W) 17" (H)@ 85#. Fan Amps: 1.5, Defrost Amps: 14.3.
Calculated load for Freezer (-10.0°F) is 9260 BTU's/hour calculated from 90 °F ambient temperature, 5276' elevation, 70 °F floor temperature, 25.56 minutes open door time per 24 hrs for(1) 30.00" X 78.00" walk-indoor opening into 90.00 °F ambient, 1.5 Watts per square foot lighting operating 10 hours per day, 0.085 occupants working 10 hours per day. All calculations ar based on data supplied by ASHRAE publications.
(1) 4 Year Extended Compressor Warranty, 3.5-5HPS
(1) 18 Month Labor/Service Warranty
Refrigeration is "sized" for holding product only; that is; our calculation is based on product entering at the same temperature as the desired temperature of this walk-in. If you feel that this is insufficient, please advise.
If Remote refrigeration condensing will be installed in ambient conditions colder than -10°F, RSG recommends an outdoor heater kit added to the refrigeration system to run sufficiently in these outdoor ambient conditions. To add this system accessory your upcharge will be $600 per system. *Standard outdoor Capsule Paks are rated to -20°F Ambient conditions. This accessory is not required.
Cooler (35.0°F) Details:
(1) 30" X 78" Walk-In Door left-hand swing
Includes door closer, cam lift hinges (one spring loaded on 36" wide and smaller doors), NL9800 deadbolt key/padlock handle with inside release, magnetic gasket, heater wire, double sweep gasket, LED vapor proof light, Heated Air Vent (standard on all freezer compartments) and NL508 combination digital thermometer and switch w/pilot light.
(1) Ramp to be Reinforced (Interior or Exterior Ramp)
(1) 30" Interior Ramp With Non-Skid Strips Applied To Top (24" Deep)
Statewide