Specifications include, but are not limited to: It is the intent of these specifications to specify the minimum requirements for the furnishing and delivery of one (1) 46,500 lb. minimum GVW rated single axle truck with Hydro Excavator Body, to be used in the Water Distribution Division the Public Services Department. The unit shall be new with less than 2,000 miles and be less than 12 months old. Unit shall be delivered complete and ready for service, as specified, and shall be equipped with all of the manufacturer's standard equipment, as advertised, whether or not specifically mentioned in these specifications, in addition to all other equipment and attachments specified herein. 1. GVW 46,500-pound minimum certified GVW. Severe duty application model only. Minimum of 114” bumper to B.O.C. 2. Wheel Base 252” Wheel base fully compatible with 9 Yard Hydro Excavator Body. Equipment supplied shall provide proper weight distribution when truck is loaded. 3. Cab to Axle 169" – Shall be compatible with a 9 Yard Hydro Excavator Body. Equipment supplied shall provide proper weight distribution when truck is loaded. 4. Frame Minimum 35 SM, 120,000 psi double channel rails, 4,400,000 RBM. 11.81”x3.54” x .5” frame rails minimum 5. Diesel Engine Final GHG17 production diesel engine equipped with SCR technology. DEF tank located in front or rear of fuel tank. 370 gross horsepower minimum. 1250 lb/ft. of torque, exhaust brake. Air Cleaner - Heavy-duty dry type with safety element. DPF filter located right hand side under cab with automatic over the road regeneration, dash mounted regen request switch, and programming to allow regen in PTO mode. Regen inhibited threshold set to zero mph. Oil Filter - Spin on full flow oil filter and oil pressure gauge, dash mounted. Warning System - High coolant temperature; low coolant, low air pressure, low oil pressure buzzer in addition to gauges, and lights, automatic shutdown 1000 Watt Block Heater & cold weather air intake warmer starting aid provision. 6. Cooling System Coolant hoses shall be Gates Blue Stripe silicone including heater hoses and constant tension hose clamps. Heavy-duty 1300 square inch minimum radiator shall be protected to minus 34 deg. F with year round coolant. An integral transmission cooler shall be provided if needed. 2 speed extreme fan drive 7. Transmission 6 -Speed Fully automatic Allison 4000 RDS with RH PTO provision. Coolant to Oil transmission cooler. A "change filter" light panel will be installed in the vehicle cab. 8. Axles Front – 16,500 lbs. capacity with dual steering gears (minimum). Rear - 30,000 lbs. capacity (minimum). Single speed full floating type, top speed 65 mph. 5.63 minimum gear ratio. 9. Springs Front – Minimum 16,500 lbs. ground capacity springs with the appropriate shock package for vehicle weight. Rear – Minimum 30,000 lbs. ground capacity. Multi-leaf spring suspension. 10. Tires and Rims FRONT: MICHELIN XZY-3 425/65R22.5 20 PLY RADIAL (Or equivalent tire.) ALCOA LVL ONE 82462X22.5X12.25 10-HUB PILOT 4.68 INSET 10- HAND ALUMINUM DISC, WITH PRE-SET BEARING IRON FRONT HUBS Front fender extension for wide base steer tires REAR: MICHELIN X MULTI D 11R22.5 14 PLY RADIAL (Or equivalent tire.) WHEELS, REAR: ALCOA LVL ONE 88367X22.5X8.25 10-HUB PILOT ALUMINUM DISC, WITH PRE-SET BEARING IRON REAR HUBS Provide spare tires and wheels: One (1) front and one (1) rear. 11. Brakes Dual air brakes system, cam brakes with dust shields, automatic slack adjusters, cast iron brake drums, compressor and accessories as required to meet all Federal Motor Vehicle Safety Standards. Shall have a low air pressure buzzer and light in cab. Also a Bendix Westinghouse air dryer (AD-9SI) aluminum or steel tanks. Air tanks shall be (DOT) approved with petcock drain valves and will be steel. 12. Cab Two (2) man cab with outer grab handles for ease of ingress and egress on both driver and passenger sides. Air suspension cab. Driver seat will be a high quality high back air suspension vinyl seat with mechanical lumbar and arm rests, or approved equal. Passenger seat will be a high back, non-suspension vinyl. Tilt/telescopic steering column Radiator protection screen. Steps into cab on both left and right side. Insulated floor mat. Safety glass in all windows. Manual Door locks. RH visibility window in door. Arm rests left and right on doors. In cab 12V power point. Driver/passenger seat belts. Dome light door operated, left and right doors. AM/FM/WB Radio with cab mounted antenna (NO MIRROR MOUNT) with factory installed blue tooth. Front mud flaps and inner fenders. Exterior cab sun visor. Manual windows.